Vulcan-Hart VEC6032 ML-114798 Průvodce řešením problémů Strana 1

VEC SERIES ELECTRIC CONVEYOR OVENSMODELSVEC301810KW ML-12619815KW ML-126401VEC4018 ML-126199VEC3624 ML-114836VEC3632 ML-114837VEC4824 ML-114838VEC4832

— 10 —ConveyorTo maintain proper belt tension, adjust the conveyor belt to remove any slack.1. Locate the two adjustment screws (Fig. 4) on the right

— 11 —2. Conveyor Assembly Removala. Remove conveyor crumb trays (see Fig. 3).b. Remove cover where conveyor shaft enters the left-hand control box (F

— 12 —e. Pull the entire conveyor assembly from the oven (Fig. 7).Fig. 7f. Take conveyor assembly to cleaning area.g. Reverse this procedure to replac

— 13 —CONVEYOR BELT ASSEMBLING AND DISASSEMBLING (Fig. 8)Install the conveyor belt so that it always runs in thedirection indicated by this arrow — th

— 14 —COOKING CHARTThe times and temperatures shown in this chart are only suggestions. Experiment with your foodproducts to determine the cooking tem

— 15 —MAINTENANCEWARNING: THE OVEN AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING,CLEANING OR SERVICING THE OVEN.WARNING: DISCONNECT ELECTRIC

— 16 —TROUBLESHOOTING GUIDEPROBLEM POSSIBLE CAUSES ACTIONPower switch is on, • Blown fuse. • Replace fuse.but oven will not operate. • Problem with po

— 2 —TABLE OF CONTENTSGENERAL...

— 3 —Installation, Operation and Care ofMODEL VEC SERIES ELECTRICCONVEYOR OVENSPLEASE KEEP THIS MANUAL FOR FUTURE USEGENERALVulcan-Hart ovens are prod

— 4 —When installed, minimum clearance from combustible and non-combustible construction must be2.5" (63.5 mm) at the sides and 2.5" (63.5 m

— 5 —Installing Stacked Ovens1. Stack ovens after basic oven is installed.2. Lift top oven and place it on top of bottom oven.3. No fasteners are requ

— 6 —OPERATIONWARNING: THE OVEN AND ITS PARTS ARE HOT. BE VERY CAREFUL WHEN OPERATING,CLEANING OR SERVICING THE OVEN.CONTROLS (Fig. 1)Fig. 1Temperatu

— 7 —Time Range Switch — Use to set cook time range from 2 to 8 minutes, 8 to 15 minutes, or15 to 20 minutes. Switch must be on cook time range desire

— 8 —A baffle (Fig. 2) is located on each end of the oven. It can be adjusted higher or lower to accommodatethe height of the product being cooked.To

— 9 —CLEANINGWARNING: DISCONNECT ELECTRICAL POWER SUPPLY BEFORE CLEANING.DailyClean the outside of the oven daily by wiping with a clean damp cloth.